DHX Circulating Fluidized Bed Steam Boiler

DHX Circulating Fluidized Bed Steam Boiler

  • Capacity:35 - 75 t/h
  • Working Pressure: 1.25 - 5.3 Mpa
  • Working Temperature: 194~485 degrees
  • Applicable Fuels: Coal, gangue, biomass, garbage, sludge.
  • Application Industry: Chemical industry, power generation, nonferrous metallurgy, paper making, rubber tyres, central heating

Introduction

The DHX circulating fluidized bed steam boiler is an energy-saving circulating fluidized bed(CFB) combustion technology based on the flow state reconstruction. It overcomes two problems of high power and high wear of conventional circulating fluidized bed(CFB) boiler. At least 30% of the use of this circulating fluidized bed boiler can be reduced, and the wear of the boiler is greatly reduced, the availability of the boiler is increased, and the maintenance and maintenance cost is reduced accordingly.

On the basis of absorbing the advantages of circulating fluidized bed boilers at home and abroad, the boiler has effectively solved the shortage of boiler wear, coking and congestion, high original dust concentration and difficulty in slag discharge by reducing circulation ratio and optimizing the structure of key parts, so as to improve and improve the original circulating fluidized bed(CFB) boiler. Therefore, the structure of the boiler is more reasonable, the performance is better, and the operation is safer and more reliable.

Performance Advantages

DHX Circulating Fluidized Bed(CFB) Steam Boiler
  • 1, High combustion efficiency: due to the intense mass and heat exchange in the fluidized bed, the exchange of unburned coal particles through multiple cycles can increase the residence time in the furnace, which is very beneficial to the burning of the fuel.
  • 2, Wide adaptability of fuel: Circulating fluidized bed(CFB) boiler can not only burn combustible coals such as bituminous coal and lignite, but also can use combustible coals such as anthracite and so on. Waste slag can be comprehensively used. The carbon content of slag is generally below 2%. Can burn bark, garbage and other biomass fuels.
  • 3, Low pollution emission: a circulating fluidized bed(CFB) boiler can obtain up to 80%--90% desulfurization rate at the proper calcium sulphur ratio and limestone grain degree; at the same time, due to the lower combustion temperature, the nitrogen oxide produced by the type boiler is much lower than that of the pulverized coal furnace. Both are lower.

Technical Data

Boiler Model Boiler Capacity t/h Working Pressure MPA Outlet Temperature ℃ Design Efficiency %
DHX35-1.25-M 35 1.25 194 89
DHX50-1.25-M 50 1.25 194 89
DHX75-1.25-M 75 1.25 194 89
ZZ-35/3.82-M 35 3.82 450 89
ZZ-50/3.82-M 50 3.82 450 89
ZZ-65/3.82-M 65 3.82 450 91
ZZ-75/3.82-M 75 3.82 450 91
ZZ-75/5.3-M 75 5.3 485 91

Live chat with our professional customer service! Get the quotation list.

Chat Now